Providing Longer Battery Life & Helping The Environment
is an Electronic Desulfation Device that conditions your battery for
It produces Higher Capacities and Longer Battery Life.
Lead-sulfate is created when a battery is discharged. When the battery
is recharged, in principle all the lead-sulfate converts back to its
component materials --- lead, lead dioxide and sulfuric acid. However,
as batteries age, lead-sulfate crystallizes on the surface of the
electrode plates. This non-conductive material coating the surface of
the electrode plate causes a reduction in the surface area needed for
electro-chemical reactions of the battery. It also reduces the
batteries' component materials (lead and acid) needed for the
reactions. As the process of discharge and recharge continues the
sulfation builds, eventually rendering the battery inoperable.
Sulfated batteries are often replaced prematurely and unnecessarily.
Nanopulser applies a weak but sharp electrical pulse that inhibits the
buildup of hard lead-sulfate crystals while gently decomposing the
crystals without damaging the battery plates.
With Nanopulser installed, batteries maintain a high capacity as well
as maximize its lifespan.
Regenerate Old Sulfated Batteries And
Maximize Capacity And Lifespan
If the old battery is not physically damaged but suffering from
buildup of hard sulfation, Nanopulser will regenerate the battery by
decomposing the hard sulfate gently and slowly. Continued use will
inhibit further sulfation build-up and maximize the battery life. The
length of the battery life depends on the condition of the battery
when Nanopulser was installed. Later, when the battery finally fails,
remove the Nanopulser and install on a new battery. This will prevent
sulfation build-up from the beginning and assure the manufacturer's
specified or intended lifespan and quite possibly extend it beyond.
In general, if the battery is 4 to 5 years old, it more likely to
revive the battery close to full capacity. However, if the battery is
already 7 to 8 years old, more likely there is a corrosion damage that
desulfation can not reverse and recover. Before installation, check
your battery for physical damages such as swelling of battery case,
white sulfation buildup outside of the case and floating particles in
the electrolyte. If found, consider the condition and expect less for
the result. Even though the Nanopulser revives old sulfated batteries,
installing to new batteries is recommended for the best result.
Learn More About Sulfation -
See How To
Install The Nanopulser
Benefits For Your Application
Nanopulser preserves a high CCA rating for the starter battery for
many years. Vehicle's electrical equipment will operate at a higher
voltage. Electric windows operate more powerfully when closing and
opening. Radio sounds loud and clear. Headlights are brighter. If you
have been driving with a weak battery, when Nanopulser is installed
you might even realize better fuel economy due to the increased
voltage efficiency of the battery.
For marine usage, batteries sulfate fast because marine vessel
batteries are usually in discharge cycle off shore. It would be common
sense to use Nanopulser for conditioning the batteries. A case study
showed an increase in the capacity of a battery in two weeks. This
battery had lost capacity and was experiencing difficulty in starting
the engine. However, after two weeks of treatment with Nanopulser, the
battery capacity came back and the battery was starting the engine
without a problem. Please be aware that using Nanopulser does not
relieve you from regular recommended battery maintenance.
Most frequently asked question for pleasure boat usage is if one unit
conditions all the batteries in a battery bank. The answer is "YES".
However, please be aware that the larger the capacity, the longer it
will take to desulfate sulfated batteries, but give a sufficient time,
Nanopulser will condition the batteries. (The sufficient time is about
4 to 6 weeks for 1000 Ah battery bank. -- based on case studies.)
R.V. deep cycle batteries also do not last long because they are
usually left unattended for long periods of time. Sulfation caused by
natural discharge is very hard. This super-hard sulfation is the worst
kind of sulfation.
Material Handling application - Forklift
In warehouse and business situations batteries are usually kept on a
good maintenance schedule and fully charged. However, the batteries
typically fail after 4 to 6 years depending on battery quality and how
well the maintenance was done. In the situation where maintenance is a
problem, Nanopulser would be very useful. Also, even with a good
maintenance schedule, we believe there is a small amount of hard
sulfation that can NOT be decomposed by regular equalization charge
based on NANOPULSER case
studies. This very hard sulfation crystal can be decomposed by
Nanopulser to maximize the life of the batteries. Even with meticulous
maintenance, Nanopulser will help assure the good condition of the
battery as a preventive measure. In addition, batteries will accept
more charges and operation hours between charges will be kept longer.
Download Your Nanopulser Brochure Here
Click Here to get a quote